Strong Smell of Gas In Vehicle (1 Viewer)

[thindart1990]

Need some advice on a strong smell of gas in the vehicle after working it pretty good on the trails. i have searched youtube and ih8mud and found that it could be caused from vapor lock. CEL diagnostic is showing potential EVAP issues. I turned it off for about an hour and it seemed to cure the smell. But curious if anyone else has had this issue and what resolved it? I have found some potential things to look at updating are:

1. EVAP lines
2. New Charcoal canister

Haven't tried either, just looking for some input on other's experiences and what I should start digging into first.

 

[Dparo]

Thread 'Gas tank building excessive pressure & fuel smell. Dangerous for sure! Why does this happen?'

Jun 12, 2020

DANGEROUS GAS PRESSURE BUILD UP IN GAS TANK!
Why?
What's going on?
How can we fix this?

Edited 3/15/25:
Since first posting this thread. I've corrected many boiling fuel. By working in this order:

1. Coolant system if first on the list, must be operating as designed. Which radiator fins cleaning is key.
2. Engine tune, so it's running at peak, is a must.
3. EVAP system must be work as design. Which I find all 03-05 and 70% of the 98-02 boiling fuel, have bad Charcoal canister.
4. Built rigs, especially with belly pans. Are directing heat onto: fuel & EVAP line and onto fuel...

• 2001LC
• Replies: 1,068
• Forum: 100-Series Cruisers

• 

 

[Dparo]

Where in Indiana are you?

 

[thindart1990]

Thread 'Gas tank building excessive pressure & fuel smell. Dangerous for sure! Why does this happen?'

Jun 12, 2020

DANGEROUS GAS PRESSURE BUILD UP IN GAS TANK!
Why?
What's going on?
How can we fix this?

Edited 3/15/25:
Since first posting this thread. I've corrected many boiling fuel. By working in this order:

1. Coolant system if first on the list, must be operating as designed. Which radiator fins cleaning is key.
2. Engine tune, so it's running at peak, is a must.
3. EVAP system must be work as design. Which I find all 03-05 and 70% of the 98-02 boiling fuel, have bad Charcoal canister.
4. Built rigs, especially with belly pans. Are directing heat onto: fuel & EVAP line and onto fuel...

• 2001LC
• Replies: 1,068
• Forum: 100-Series Cruisers

• 

Thanks for this! Sounds like first step will be the charcoal canister. I’ll be addressing that asap.

 

[Super77]

Have you tried changing your gas cap? Much cheaper place to start, especially if it’s not OEM.