- Location
- United States
1980 BJ-40, 3B engine, turbo, sale or partial trade, NORCAL
Rare 1980 BJ-40, originally from Costa Rica. Non NA, Warm climate BJ-40 with no AC/heater and no amenities other than aftermarket stereo/seats. Designed by PO for safety and reliability. 3B diesel engine - originally a "b" type engine but replaced by PO to "3b", PO purchased 3b from company in Canada (unk. miles/km on engine when installed but known to last upwards of over 500k plus); owner installed Nissan turbo, custom aluminum (appears to be four core) radiator with thermostat controlled electric fan; 4 speed, 4wd, 12 volt, stock gears (i believe 4:11, no lockers), locking hubs, after market 4 wheel disc brakes w/large dual master w/booster, Iron pig off road skid plate (have original), Proffitt's Cruiser designed and installed full family roll cage (attached to the frame in four places) and rear tow bumper with tire/ hi-lift jack carrier; interior has sprayed in liner, aftermarket front seats with four point seat belt, original rear toyota jump type seats (not installed- have to adjust mounting due to full roll cage); runs great. ARB front bumper with Warn 8274-50 winch. Front turn signals were removed. Front LED turn signals are in the ARB bumper. Original miles (km speedometer) may be over 54, 000 km. Runs great. California registered and legal. PO had purchased BJ through importer in California. PO lived in NM. Also had been registered and titled in NM.
Body: original body, looks great but appeared to have been redone (body worked). Per PO bodywork probably done in Costa Rica. Body looks good. Has some areas that could be sanded down and smoothed over. Two front fenders have rust where side steps connect to the fenders. I have two good mid 70 era fenders, hood and grill that will go with the BJ-40. Roof is in great condition no rust through. Rain gutters are solid. D/P front doors are in great condition. Does not appear to have any body work. Very minor surface rust, if any under rubbers gasket. The ambulance doors are in great condition. The driver side has a dent on the exterior side toward the bottom. Overall body is great. Windshield is solid. Remember it is a 30 year old vehicle.
Tires are off brand 33x12.50x15 mud terrains with about 3/4 left. Rims are "Weld" rims 8x15". Tuffy center console. EGT/Boost and new water temp. gauge. Has rear engine seal seep. Horn/windshield washer container and emergency blinkers do not work.
Extras: Best top "sail cloth" full top. Power steering pump, gear box, pulley and brackets for 3B power steering. The rear parking brake, which is connected to the rear of the transfer case, works but is marginal at best. LC will come with the attached hi-lift jack.
The BJ-40 also has aftermarket leaf spring packs which lifts it about 2" to 2 1/2". There are "pro comp" shocks. There are braided (stainless steel?) brakelines at each caliper/disc brake. Stops very well. The 40 is no speed demon but can keep up with traffic (Especially with the turbo). Would probably have better acceleration and top speed with 4.56/4.88 gears or 30" to 31" size tires. Lots of low end torque. Also should note that the manual steering gear box seeps. I never worried about this because I was planning to eventually install power steering (p/s parts are included in the purchase of the BJ-40).
Priorities have changed and I want to modify my FZJ-80 instead. Not desperate. Just an extra, unique vehicle.
Additional extras: For full price it includes: H55F and transfer case for Toyota diesel B series engine. New clutch/disc kit. Special rear brake drum for back of transfer case so rear brake works better. (Also may be taking off the hardtop to put on the soft top for the summer.)
Have additional photos. Please email to: kz195688@yahoo.com Thanks.
$18,500.00/ OBO or trade plus cash
Rare 1980 BJ-40, originally from Costa Rica. Non NA, Warm climate BJ-40 with no AC/heater and no amenities other than aftermarket stereo/seats. Designed by PO for safety and reliability. 3B diesel engine - originally a "b" type engine but replaced by PO to "3b", PO purchased 3b from company in Canada (unk. miles/km on engine when installed but known to last upwards of over 500k plus); owner installed Nissan turbo, custom aluminum (appears to be four core) radiator with thermostat controlled electric fan; 4 speed, 4wd, 12 volt, stock gears (i believe 4:11, no lockers), locking hubs, after market 4 wheel disc brakes w/large dual master w/booster, Iron pig off road skid plate (have original), Proffitt's Cruiser designed and installed full family roll cage (attached to the frame in four places) and rear tow bumper with tire/ hi-lift jack carrier; interior has sprayed in liner, aftermarket front seats with four point seat belt, original rear toyota jump type seats (not installed- have to adjust mounting due to full roll cage); runs great. ARB front bumper with Warn 8274-50 winch. Front turn signals were removed. Front LED turn signals are in the ARB bumper. Original miles (km speedometer) may be over 54, 000 km. Runs great. California registered and legal. PO had purchased BJ through importer in California. PO lived in NM. Also had been registered and titled in NM.
Body: original body, looks great but appeared to have been redone (body worked). Per PO bodywork probably done in Costa Rica. Body looks good. Has some areas that could be sanded down and smoothed over. Two front fenders have rust where side steps connect to the fenders. I have two good mid 70 era fenders, hood and grill that will go with the BJ-40. Roof is in great condition no rust through. Rain gutters are solid. D/P front doors are in great condition. Does not appear to have any body work. Very minor surface rust, if any under rubbers gasket. The ambulance doors are in great condition. The driver side has a dent on the exterior side toward the bottom. Overall body is great. Windshield is solid. Remember it is a 30 year old vehicle.
Tires are off brand 33x12.50x15 mud terrains with about 3/4 left. Rims are "Weld" rims 8x15". Tuffy center console. EGT/Boost and new water temp. gauge. Has rear engine seal seep. Horn/windshield washer container and emergency blinkers do not work.
Extras: Best top "sail cloth" full top. Power steering pump, gear box, pulley and brackets for 3B power steering. The rear parking brake, which is connected to the rear of the transfer case, works but is marginal at best. LC will come with the attached hi-lift jack.
The BJ-40 also has aftermarket leaf spring packs which lifts it about 2" to 2 1/2". There are "pro comp" shocks. There are braided (stainless steel?) brakelines at each caliper/disc brake. Stops very well. The 40 is no speed demon but can keep up with traffic (Especially with the turbo). Would probably have better acceleration and top speed with 4.56/4.88 gears or 30" to 31" size tires. Lots of low end torque. Also should note that the manual steering gear box seeps. I never worried about this because I was planning to eventually install power steering (p/s parts are included in the purchase of the BJ-40).
Priorities have changed and I want to modify my FZJ-80 instead. Not desperate. Just an extra, unique vehicle.
Additional extras: For full price it includes: H55F and transfer case for Toyota diesel B series engine. New clutch/disc kit. Special rear brake drum for back of transfer case so rear brake works better. (Also may be taking off the hardtop to put on the soft top for the summer.)
Have additional photos. Please email to: kz195688@yahoo.com Thanks.
$18,500.00/ OBO or trade plus cash
Last edited: