wear

  1. dudwire

    H150F and HF1A Rebuild Common Wear Points

    Hi Everyone, I'm about to have a go at rebuilding a H150F & HF1A. I have a 2003 HDJ79 with 470,000kms, the gearbox is making a noise from the input shaft at idle when cold and the transfer is making quite the noise when put in neutral with the gearbox in gear at idle. Raising the RPM above 900...
  2. S

    Transfer case output spline wear?

    Been chasing a loud whine in transfer case along with a fair bit of slop/lash. I just started pulling it apart and it appears that the output gear splines are pretty loose on the shaft. I have heard that the output gears and bearings are not supposed to be tight on the output shaft, but this...
  3. sunrk

    Tread cracking in 7 yr old A/T tyre that has basically nil wear

    Found this tread cracking in a 7 yr old but almost nil wear Hero Dynastorm A/T tyre currently on left rear position of my 80 series. This tyre/wheel is one that was on my box trailer since 2016 until very recently. Is this enough cause to replace the tyre? I have two more of these Hero...
  4. 7000ft

    NITTO Ridge Grappler wear after 25,000+ miles

    I'm posting this for those considering NITTO Ridge Grappler tires (LT285x65x18E). Tire tread depth @new: 16.5/32" After 25,000 installed miles: 11/32" ( all around) Tire pressure:42psi Rotated every 5,000 miles
  5. rloaderro

    Is differential wear normal?

    I always thought the differentials and gear cases (transfer excluded) were indestructible.. is it normal a 40 rear differential can get so much wear the teeth will break?
  6. PeterTheBeater

    Odd rear tire wear

    Got a 97 FJZ80, running 35” Cooper STT Pros (E) about 1.5yr old. Got Fox 2.0 extended shocks, about 1.5yr old. OME mystery springs. The rear tires are having a funny wear pattern, almost feather like. Can’t notice anything in the front, maybe some odd wear before the rotation. No vibration or...
Back
Top Bottom