Left side differential seal leaking again a month after replacement. (1 Viewer)

This site may earn a commission from merchant affiliate
links, including eBay, Amazon, Skimlinks, and others.

Joined
Jul 21, 2014
Threads
67
Messages
532
Location
Under my cruiser
Website
www.youtube.com
@2001LC I have replaced left side differential seal a month ago and it was holding up fine, yesterday after inspection, I found it leaking again. What are your thoughts on it?
How far in the oil seal need to go inside the differential tube, I was jacking up the car on the right side to replace some bushing, could it be tilting that cause the diff oil to come out on the left side?
 
Leak/weep after seal replacement is ‘usually’ due to installation error. Other factor cam be bent axle which I hope is not the case. And yes a clogged differential breather can create pressure in the axle housing that can lead to seal failure.
 
These are the pictures of the old oil seal. I believe the older oil seal wasn't seated properly that's why it was leaking and maybe I have made the same mistake when installing new seal. I wasn't sure how far in I need to push the seal.
1 Large.jpeg
2 Large.jpeg
 
that does look too far "pushed in", but I haven't done this job in a while.
another thing is there could be a wear mark on the shaft itself, where the old seal was sitting. you could try to install a new seal slightly less deep so the seal rides on a different part of the shaft
 
Seal is genuine, bought it from partsouq. I am thinking maybe the diff breather is clogged but I haven't inspected that yet.

Definitely check this out, the breather. It should always be the first point of inspection for a diff leak, imo.
 

Users who are viewing this thread

Back
Top Bottom