transfer case

Picked up a fixer upper 40 that needs a transfer case for my stock 4 speed transmission.

Any one want to guess how many different shift patterns and drive trains there are for the FJ40? Well I’ll tell you it’s ridiculous. I’ll tell you at the very end of this post. I recently learned Advance Adapters makes a transfer case that you can connect an Automatic Transmission to. So after...

I'm about to go replace the output seal on my transfer case and trying to mentally walk through the job before tearing into it. Can the rear extension housing be removed with the crossmember still bolted to the frame rails? Planning to replace the output seal, bearing, snap rings, speedo...

Out of an HZJ77, 1992, 150k km on both. It is a part-time transfer case. Asking $900 $500 for both. Must be picked up, will not seperate. Sold together.

I have a 1980 FJ40. It has had the original trany & transfer case until recently where I needed lower gearing for crawling. My question is that I have lengthened the drivetrain about 4-4 1/2”. There was no crossmember to support the drivetrain, will extending it out the 4” make much of a...

Looking for transmission and transfer case for 1994 LC FJ80 - OEM parts numbers above. Thanks.

Hi h8ers, a bit of a transfer case issue going on… My 1975 stock fj40 does not shift from 4 low back to 4 high every time. Every 4 or five times I off-road it, when I shift back into 4 high, it does a buzz-wherr when I drop the clutch, and doesn’t move forward. I have been able to get it to...

Wasn't leaking when I took engine out two years ago, why would this suddenly be leaking? What am I in for in terms of fixing this myself, full dissasmebly? can one "ignore" a common leak like this? Here's a free pic of my finger covered with what is on there (youll have to pay for pics of full...

‘79 FJ40 4 speed transmission and transfer case. Purchased from a fellow Mudder years ago and never used. Been stored inside a shed since I had it, but looks like it may have been outside before. Price $300 local pickup ‘79 Bellhousing 2F $100 local pickup ‘79 Flywheel 2F $75 local pickup...

I have a split transfer case and am putting it together. The shift lever going to the shift fork operates correctly until I tighten the shift detent ball/spring/bolt on the top of the case down and then it’s not shifting as it should. (It’s like it’s locking up the shift fork). Anyone have any...

This is a Transfer Case Rebuild Kit - Fits 3 Speed 1963-9/1973 4x/5x Series. Brand new. Bought 10+ years ago and has sat in garage. Koyo bearings. $100 + shipping

This is the adapter by Jerry Nichols of Colorado Offroad Express and built by Advance Adapters. Will bolt a NP203 low gearbox to a TLC 19 spline transfer case. Been sitting in the garage for longer than I care to say. Moving out of country and so I'll never use it. Hope someone else can. $150 +...

I am getting this fault code, and I am searching for the correct switch sensor to replace on the transfer case? Any direct knowledge on this error code? Also, getting PRNDL switch fault as well, but I think that’s tied into the A/TP warning light I’m getting.

Aisin carb from a ‘75. Just a rebuildable core, but I think it’s all there (someone please correct me on that if that’s incorrect). Located in southern middle TN. $75, obo, plus shipping. I have never used this carb, it was just in boxes of parts that came with my 40 when I bought it years ago...

I just picked up a 2001 for my daughter and it’s in pretty good shape. We have a few thing to address as normal with LCs of this age. The A/TP warning light is on at start up and goes away once placed into gear, Drive, reverse etc. I thought this was just a warning when transfer case hits...

I can shift the transfer case high neutral low easily. But nothing happens when it's on neutral or low. The SUV doesn't move. When I shift to high, it moves. My parents have been driving this way for about 10 years. I planned on fixing this issue. Give me some ideas! Tomorrow I plan on changing...

I've seen some posts in this regard but wanted to see if there is advice on my situation...noise when accelerating mostly in 4th...changed transmission fluid sounds a bit better but still noise. Any advice on cause? Would transfer case create what I'm hearing? Thanks!

Tranfercase swap question. I am rebuilding my FJ40 75 (12/74) 4 speed, but I have some issues with the 4 speed transfer case. I have a 3 speed transfer case that is rebuilt and ready to go I got in trade. The input bearing is 29 tooth with 10 spline in the transfer and mine has a 29 tooth 16...

Hi everyone, Hoping to get some ideas on what may be causing this grinding noise which seems to be coming from the transfer case area. The truck is a 1979 BJ40 with a 4 speed transmission. The noise occurs in all 4 forward gears (while moving) and does not occur in reverse. When the clutch is...

Hello all, in research today it looks like I have found this aisin part #. SAT 012. Can any techs confirm this is the OE part lexus would sell for the transfer case actuator? It's listing between 4 and 500, vs the 1200 for the part. Hope this can save some one some money if we can confirm it. Cheers