transfer case

I need a 3sp transfer case for a build i am doing. I am located in Colorado. I also need a FJ40 rear axle.... Thanks, Ben

SoCal $100 including shipping for sensor. Also cluster guages except speedometer Please message if interested or questions. Without this sensor, your speedometer will not work.

Looking for a 66 fj40 transfer case knob in good shape. Regards

Hi folks. I'm looking for someone in this community with intimate knowledge of the HF2AV transfer case. I want you to tell me "You don't have to take your t-case apart again to install this. It's an over-engineered part designed by lawyers, and is not needed." Here's the story. I installed a...

Hey guys, I have a stamped 1966 fj40 (probably a '64 judging by the serrated top) and I converted from 3 on the tree to an fj40 h42 but kept my 3 speed original T-case. Two questions: -Can I use my original PTO gear with that setup and run a PTO or do I need a 4 speed PTO gear in my transfer...

I have a 1974 FJ40 with spun bushings for the lower output shift gears. Ordered replacements and received bushings that fit a 75 not a 74. Any suggestions on who to call to order two bushings so that I can finish putting the transfer case together. If bushings are not available can I buy the...

Hey all Over the past few months, I have been getting a progressively louder gear noise coming from the transfer case over ~20MPH...Here's some more info: 1.) TCase work done by a local shop approx 5 years ago (overhaul w/new shims, bearings, races and seals) 2.) Gear noise only when under...

SOLD!!! I'm helping out a friend who's parting out his now abandoned truggy crawler project. Most of it's already gone to friends & family. BUT..... I offer to you, today, a 5 speed trans (was told this is the '95 version with bigger bearings) from a 22R truck. This was gone through by...

I am trying to find Koyo bearing numbers for a 1966 FJ40 three speed transfer case seen in the following picture: Does anyone happen to know these numbers? Thanks.

In SoCal UPDATED: SEPT 21, 2017 1995-1997 Transmission 1993-1994 Transmission 1993-1997 Transfer Case 1991-1992 Transfer Case Shift Control Modules also available. Driveshafts available: 1991-1992 1993-1994 1995-1997 Personal Message for quotes. I have lifting...

I've got an H55 + Toybox + splitcase in my Troopy. I'm thinking about installing a transfer case saver bypass hose. (I had the input shaft seal go bad in a different splitcase 10 years ago and it pumped most of the transfer case lube into the H41 wrecking the transfer gears fairly quickly.)...

pulled from a 1981 BJ42 with unknown milage 19 spline input / 22 spline output needs new seals no bell housing everything worked fine when installed $600 pickup only in Denver, CO area

1977 FJ40 4speed and transfer case Came out of a parts vehicle with 77k on it. $500

I have several of these in good working order $250 Buyer pays shipping/freight from 32605. 125#

Hello fellow gear heads, Just recently did a rebuild on my Transfer case, when we re-installed everything I am finding it harder to change transmission gears (1st-4th) while driving. We didn't touch the transmission other than to disconnect and drain the old fluid, but other than that we didn't...

Hi, I just got the clutch changed in my A442F, shifts very smooth, runs well, but after we fitted the tranny back, noticed a grinding shift when playing around with the transfer case, its like gears struggling to sync in. Now this happens when the truck's engine is on but when in dead slow, but...

For sale 3 speed tranny and transfer case out of a 72. Transmission shifts smoothly. Transfer case shifter is stuck but output shafts spin fine. $400 $250 150 p/s OBO Located in Buffalo, NY

Hey fellas, I have a transmission that needs a rebuild and a transfer case that functions properly. For the transmission, it had issues shifting from first to second. According to the dealer, it overheated while I was towing a uhaul. The transmission and transfer case are still connected. $350...

Looking for a complete FJ40 3 speed transfer case to finish a build. What you got???

Trying to help my friend that realized he had missing pieces from his rebuild that stopped him in his tracks. He's got a 1972 FJ40 and the F motor is rebuilt and he bought a 4 speed transmission to switch it over. WHAT transfer case will work with this setup and does anyone have one for sale...