Search results for query: *

Forum search Google search

  1. Rockiemosley

    Companion flange sealant?

    Im changing out the seals that go on the companion flange output shafts on my FJ60 transfer case. The front output had some sealant on the splined shaft where it fits into the companion flange. Is there supposed to be some sealant here to prevent transfer case oil migrating out through the...
  2. Rockiemosley

    Windshield wiper motor overhaul- Klixon overload protector

    I wanted to present this bit of info to the community as I think I discovered something that I have not seen mentioned and its something that alot of FJ60 owners might be struggling with. I have been unhappy with the slow speed of the wipers in my 1985 FJ60 for quite a while. After greasing all...
  3. Rockiemosley

    Wiper harness dongle

    Im trying to diagnose poor and or no wiper performance on my 1985 FJ60. I have searched high and low to figure out what this connector is for that goes between the wiper motor and the vehicle harness. 2 of the wires are potted into a gizmo. Nothing i can find in the FSM about this. Anybody know...
  4. Rockiemosley

    Would tgese wheels work?

    I am considering putting some FJ cruiser wheels on my 1985 FJ60 with a four-speed transmission. The tires on these wheels are 265/70-17. Im wondering how the truck will drive with these wheels and if it might be a halfway decent substitute for a 5 speed gearbox, allowing me to get up to modern...
  5. Rockiemosley

    Missing bolts?

    I was crawling up until my cruiser today and it looks like im missing 2 of the bolts that hold the gearbox to the bellhousing on my FJ60. It’s been like that for years but I suppose that I need bolts here. Would anyone have a couple of these bolts I could buy ?
  6. Rockiemosley

    Harmonic Balancer Nut install

    I am in the final stages of re assembly on replacing the harmonic balancer in my 1985 FJ60. I have searched the boards but still can’t decide if I should locktite the big nut that holds the balancer on, and how much torque. I used a jack handle pipe on the wrench to get it off. I don’t have a...
  7. Rockiemosley

    Oil cooler flow direction?

    Does anyone know if oil runs through the oil cooler before or after the oil filter? My oil cooler was rusty so I took it off to sandblast, and despite my best efforts, I got some sand inside it. I have since flushed it out over and over with gasoline and im 98% sure that I got all the sand out...
  8. Rockiemosley

    Oil plug weep hole

    Can anybody explain why my FJ 60 has this little tiny weep hole at the bottom of the sump plug. My theory is that it is a rust prevention device designed to bathe the underside of the truck with a coating of oil, which it does pretty well.
  9. Rockiemosley

    Piston rings

    Would anyone know where I might buy piston rings for just one cylinder? Due to a over heating mishap, I am replacing one piston in my 1985 FJ60 and I see SOR has single pistons available but only full sets of rings apparently and I just need rings for one.
  10. Rockiemosley

    Simplifying heater hose routing.

    I have a 1985 FJ60 that until recently was running original heater and radiator hoses from 1985. I am redoing all the hoses, and I want to simplify a few things. First off, I want to bypass the rear heater since it never gets that cold where I live, and its one less thing to go wrong...
  11. Rockiemosley

    Heater hoses

    On my 1985 FJ60, I am in the process of replacing all the radiator and heater hoses. My question is... Although it is nice to have a rear heater, I live in North Carolina where it rarely gets very cold....wouldnt it be sufficent to just have the heater under the dashboard, and bypass the rear...
  12. Rockiemosley

    Wiring radio

    I am trying to identify this bundle of wires near the radio in my 1985 FJ60. There was no radio in this truck when I got it. The fat red wire with blue stripe is hot with ignition key on, so I assume that is to power the radio, but I would like to figure out what the other wires are for. Ive...
  13. Rockiemosley

    Speakers in front doors

    I am trying to mount some speakers in some FJ60 doors that are missing speakers. Shouldn’t there be some sort of plastic cup behind the speaker to protect it from moisture inside the door? That would seem to be a good upgrade anyway. My vapor barrier behind the door card is somewhat tattered...
Back
Top Bottom